Lucas Industries EM-C061 Manual do Utilizador

Lucas Control SystemsDeeco SystemsEM-C06114" Flat Panel DisplayEmbedded Computer ModuleUSER MANUALManual P/N: 15062Manual Revision: 1.0Manual R

EM-C061 Computer User Manual4Floppy Drive❏ 600 Mounted Floppy Drive (Rear Access)PC/104 Semiconductor Disks❏ 1010 2MB on PC/104 Card❏ 1011 8MB on P

EM-C061 Computer User Manual51.5 SPECIFICATIONSCPU Pentium processor up to 200 MHzL2 Cache 512K pipeline burst modeDisplays 13.8" XGA (1024 x 76

EM-C061 Computer User Manual61.6 DISPLAYThe display is color active matrix LCD incorporating amorphous silicon TFT. Graphics and textscan be displaye

EM-C061 Computer User Manual72.0 INSTALLATIONRead this section prior to installing the computer. Following these steps will ensure a successfulinstall

EM-C061 Computer User Manual82.2 MOUNTINGThe EM-C061 is designed to be mounted in enclosures, rack-mounted, mounted in walls, andintegrated in systems

EM-C061 Computer User Manual924 VDCReturnGroundLineNeutralGround2.4 POWER REQUIREMENTSThe following table specifies the electrical requirements and ca

EM-C061 Computer User Manual10Customer Supplied ±5, ±12V:Connect ±5, ±12V and Ground to the pigtail as shown:+5VGroundGround+12V-12V-5V

EM-C061 Computer User Manual113.0 Single Board Computer OperationThe separate Single Board Computer (SBC) user manual contains setup, operation, and

EM-C061 Computer User Manual134.0 Touch SystemRefer to the manual on the Touch Driver Diskette for information on the optional touch system.Touch driv

EM-C061 Computer User Manual155.0 Input/Output Interface Ports5.1 SERIAL COMMUNICATIONS PORTThe computer includes two serial ports, configured as COM1

EM-C061 Computer User Manual165.2.2 Parallel Port ConnectorThe parallel port uses a 25-pin IDC style DSUB. The pin out for the connector is:Pin Dir Na

EM-C061 Computer User Manual175.3 KEYBOARD PORTThe computer supports an AT style 101 Keyboard.Keyboard Connector(Rear View)Pin Signal1 KeyClk2 KeyData

EM-C061 Computer User Manual185.4.1 10 BASE-T ConnectorEthernet Network InterfaceRJ45 Connector Pin-Out12345678Front ViewPin Signal1 TX+2 TX-3 RX+4NC5

EM-C061 Computer User Manual19 6.0 Data Storage6.1 HARD DRIVES:Drive Type1.3GB, rugged 2.5″ PIO4 (EIDE)2.0GB, rugged 2.5″ PIO4 (EIDE)2.11GB, 3.5″ Ultr

EM-C061 Computer User Manual217.0 General MaintenanceThe bezel and filter are made of a plastic polymer material, so strong solvents or acids should

EM-C061 Computer User Manual238.0 TroubleshootingLucas Deeco maintains a repair facility at the factory and at various international locations. CallTe

How to contact Deeco Systems for sales or technical support:Lucas Control Systems, Deeco Systems31047 Genstar RoadHayward, California USA 94544-7831Ph

EM-C061 Computer User Manual24Problem: Malfunctioning DisplaySub-System to Check:• Display• Single Board Computer Motherboard (Refer to the accompan

EM-C061 Computer User Manual258.1 POWER SUPPLY• Input Power:Check to see if the input power to the power supply meets the requirement in section 2.4

EM-C061 Computer User Manual268.2 TOUCH INTERFACE J0 •1 2 3 4 5 6 7 8 9 10 11H1Power 1x2 MRS-232 Serial 2x5 MAccuTouch 1x5 ML Y S X H5P3P2P4E

EM-C061 Computer User Manual278.3 DISPLAYVerify that the cable is properly connected to the SBC. Replace the cable as a part of test procedure.If disp

EM-C061 Computer User Manual299.0 Component Test Procedure9.1 POWER SUPPLYThis section details the procedures for testing the functionality of the pow

EM-C061 Computer User Manual30• Output Power:Using a multi-meter set for DC voltage, measure the potential between ground and the pins inthe followin

EM-C061 Computer User Manual31If no output is measured, disconnect the power supply from source voltage and check the fuse on thepower supply board.•

EM-C061 Computer User Manual3310.0 Component Installation and RemovalRear View

Warning!!Grounding circuit continuity is vital for safe operation of the machine.Never operate the machine with the grounding conductor disconnected.S

EM-C061 Computer User Manual34Right Side View(Viewed from Front)Left Side View(Viewed from Front)

EM-C061 Computer User Manual3510.1 TOUCH CONTROLLER BOARD10.1.1 Removal• Place the computer face-down on a flat surface.• Remove the 5-pin touch scr

EM-C061 Computer User Manual3610.2.2 SIMMs Installation Figure A Figure B(Photo used for illustrative purposes only. Models and configurations ma

EM-C061 Computer User Manual3710.3 MICROPROCESSOR REMOVAL AND INSTALLATIONRemoving the microprocessor from the socket(Photo used for illustrative purp

EM-C061 Computer User Manual39Appendix A: Mechanical DrawingsA.1 EM-C061 COMPUTER FRONT VIEW 11.5"(292 mm) 14.4" (366 mm)Note: Dimensio

EM-C061 Computer User Manual40A.2 EM-C061 COMPUTER REAR VIEW 11.5"(292 mm)14.4" (366 mm)TouchControllerSBC in Standard ModelCard Slots (2

EM-C061 Computer User Manual41A.3 EM-C061 SIDE VIEW2 PCI Slots2 ISA SlotsSBC 11.5"(292 mm)6.2" (157 mm)with backplane4.0" (102 mm)with

EM-C061 Computer User Manual42A.4 EM-C061 CABLING DIAGRAMDisplayTouchscreenTouchControllerSBCCOM1COM2LPT1KYBDSCSIControllerSCSI HDDSCSI HDD OptionIDE

EM-C061 Computer User Manual43A.5 EM-C061 PANEL CUT-OUTS AND MOUNTING GUIDE Suggested Panel Cutout for Mounting the EM-C061 Computer without the opti

iTable of Contents1.0 OVERVIEW...

EM-C061 Computer User Manual44 Suggested Panel Cutout for Mounting the EM-C061 Computer with the optional front panel 11.60" (H) x 14.50"

EM-C061 Computer User Manual45Appendix B: Product Naming ConventionEM - C 0 6 1Platform Type Processing ConfigurationST Enclosed SystemEM Embedde

EM-C061 Computer User Manual46Display Nomenclature3 f d sSequential number IDSize of display (same as specified in base unit ID #)1 NA 3 10.4” 5 12.1”

EM-C061 Computer User Manual47Limited WarrantyLucas Control Systems warrants this product against defects in materials and workmanship for aperiod of

EM-C061 Computer User Manual48LIMITATIONS OF LIABILITYTHE BUYER AND LUCAS CONTROL SYSTEMS AGREE THAT THE SOLE AND EXCLUSIVEREMEDIES FOR BREACH OF ANY

EM-C061 Computer User Manual49Index110 BASE-T Connector, 18AApplying Power, 8BBIOS, 23, 24DDiagnostics, 2DOS, 2EEthernet, 17FFuse, 31GGreen PC, 2IInpu

EM-C061 Computer User Manual50LLAN, 17LCD, 47MMounting, 8, 35Mouse, 2, 17NNovell, 2OOS/2, 2Output Power, 25, 30PParallel Port, 16Power, 2Power Require

EM-C061 Computer User Manual51WWindows, 2

ii8.4 SINGLE BOARD COMPUTER...279.0 COMPONENT TEST PROCED

EM-C061 Computer User Manual11.0 OverviewLucas Control Systems, Deeco™ Systems offers a complete line of rugged computers, VGAmonitors, and terminals.

EM-C061 Computer User Manual2 1.2 INDUSTRIAL COMPUTERSDeeco computers are designed for industrial conditions and exposure to harsh environmentsincludi

EM-C061 Computer User Manual31.4 ORDERING INFORMATIONBase System ConfigurationSelect a Computer and Chip Set *a❏ 123 Full Size ISA/PCI SBC, 100 MHz Pe